Search results

Replaced the Evaporator over the weekend because it was leaking, also replaced the heater core as well as the AC Accumulator. Let the system sit with a vacuum on it for an hour after everything was reassembled, it held fine. Charged the system, it worked for about 2 days, and now the compressor...

Last year I went through the entire cooling system, due to cracked head on 01. Replaced head/gasket/bolts, etc. Also installed new radiator, hoses, thermostat, thermostat housing, water pump. No issues, until last week. It has recently gotten pretty cold here in central IL, so I went out before...

2001 Cherokee XJ with the LP Dana 30. RE 3.5" Super ride lift and 31's. Advanced adapters SYE with tom woods' rear shaft. Getting rhythmic vibes around 55 mph, and they progressively worsen thereafter. I shimmed the rear with a 3° shim, and the vibrations stop when the front shaft is...

Just a quick question on a clearwater head install that I did on my 2001 XJ last night. Went through the proper torque procedure, 22, 45 (x2), then 110 on all bolts except 11 (drivers side front), which was 100 with thread sealant. I went through and checked them all again at 110, but on the...

Replacing head with Clearwater cylinder head, trying to determine which head gasket set to use? Bolts I plan on using ES71102 set. Thanks!

Hey guys, I've got a 2001 cherokee sport with 72,000 miles on it. Coolant had a muddy look to it, and the reservoir was empty, so I assumed the head crack. However, the the top end and crank case oil showed no signs of coolant entry. So as a precaution, I decided to go ahead with the...

I've got a 2000 XJ that I'm installing the RE 3.5 kit on. Rear leafs, are so far as bad as described, as far as removal. Passengers side wasn't horrid, but the drivers side front bolt decided to bust the weld nut off so the bolt just spins. No prob, I'll just go in through the floorboard to...

Does anyone know where I can find these things? I removed the a pillars to do some wiring and the clips broke off. So I ordered two new a pillar trim pieces from Jeep Classic Parts (local dealership), and they came with the retaining clips not attached... The factory ones were melted on it...

Hi all, I recently replaced the water pump on my 2001 XJ and while I was at it replaced the temp sensor and the outlet pipe leading to the heater core. I ordered these parts through Chrysler and when they came in they both had what looked like orange thread sealant (which was hard-ish) applied...

I picked up a 2001 Cherokee Sport a few months ago, and my wife and I were going to use it this spring as we storm chase and travel in the spring/summer. I am in the process of doing plugs/changing fluids, but have read that one of the best things that can be done is to update/overhaul the...

I briefly considered that this could be because of the lockout switch on the drivers side, but I'm not positive. Here are the symptoms: Passenger side power window swith does NOT activate the window up/down. Drivers side window switch DOES activate the passenger side window up/down. The...

Long story short, I recently picked up a 2001 cherokee xj, and was doing the big 3 upgrade, battery positive to alternator positive, battery negative to chassis and engine to chassis. I've seen a lot of guys, rather than add an additional ground to the engine block, they just grounded the...

Hey, I needed a little help finding a couple parts. I had the interior out of my 2001 Cherokee Sport doing a little work, and managed to snap the tabs off of the A-Pillar trim piece (drivers side). I tried gluing them back on, and reusing the piece, but it's just not working. So I would...

2001 Cherokee, I took the carpet out to shampoo it and I'm putting in a small amp and sub, so I'm running the wiring for that. While it was out I was going to coat the entire interior floorboards with something like POR 15 or Chassis Saver. However, when I got the carpet out, there is VERY...

Hi, I recently picked up a 2001 Cherokee Sport after a bunch of time searching. It's black and has 72,000 miles on it. It seems to run well for being 13 years old, but the suspension and steering does seem a bit "lose" if you will. I'm just wondering at 72,000 miles what parts of the...