Search results

Anyone know where I can purchase a rebuild kit for a 1987 XJ Dana 44 Trac-lok limited slip? I have 3.43 gears which means I have the smaller of the two ring gear carriers. The kit should have clutches and springs, maybe the little gear as well. Thanks!

Hi All, I've swapped a '87 Dana 44 into my '92 XJ 4 door 4x4 I6 auto transmission Jeep. I want to purchase wheel cylinders for the 10" x 2.5" drum brakes on this D44 axle. The wheel cylinders presently on this D44 axle have the brake tube fitting that screws into them somewhat from the...

I have a 1992 XJ 4.0 with auto trans. There is a electronic control module (ECM) in the engine bay on the driver's side just behind the radiator and next to the air box. My ECM is working now but it is 32 years old. Someday it will die. When this happens, can a new ECM be purchased? How...

1992 4-door Jeep Cherokee XJ with 4.0 6 cyl engine and AW-4 auto trans. Date of purchases 2023AUG Userful NAXJA reference thread https://www.naxja.org/forum/showthread.php?t=1100177&highlight=air+conditioning The project goal was to replace all A/C parts, except the evaporator, with new and to...

Hi All, I have a 1992 XJ 4.0 Liter 4X4 with AW-4 auto trans. This vehicle has a transmission cooler. I would like to add a filter in the transmission cooler line. The filter has a preferred direction of flow. I need to know which way to install the filter. AW-4 has two cooler line...

I have a 1992 XJ 4.0 4X4 with the AW-4 auto transmission. I have purchased a remanufactured AW-4 and intend to swap this remanufactured trans with the trans presently in the XJ. I am also removing the 4.0 motor. Which is better... Remove the 4.0 motor and then remove the transmission... or...

Hi All, I would like to replace some sensors on my 1992 XJ 4.0 4x4 Auto trans. I need to know the proper names so I can purchase. I see two electrical connections to things on the throttle body. I suspect these are not sensors but solenoids of some sort. What are their names? I see one...

Hi All, I have a 1992 XJ 4.0 4x4 with AW-4 auto tranny and tow package. My AW-4 has 400K good miles on it and it still works fine. But with all the miles the time will come soon when the AW-4 dies. I've gotten enough miles and would rather rebuild AW-4 before it dies on the trail. I plan to...

I have 2 unit of XJ Driver Side Door support as described at https://www.hooliganoffroad.com/products/xj-door-hinge-support I'm in Encinitas, San Diego's North County. I'll sell each at $30. Pickup in Encinitas. Mike

Just a quick note concerning Hooligan XJ Door Hinge Supports. I purchased and installed the driver's side on my 1992 XJ 4X4 4.0 Automatic. Overall the job difficulty was moderate. Fender must come off and is retained with a dozen or so sheet metal screws. Relatively easily removed. Hooligan...

Hi All, I have a 1992 XJ 4.0 auto trans with stock D30 front axle. There are 4 suspension arms that secure this axle to the body and allow the axle to travel up/down against the force of the 2 coil suspension springs. This is the factory stock arrangement for this XJ. My 4 arms are OK but...

Hi All, I have a 1992 XJ Laredo with 4.0 I6 and AW4 Auto Transmission. It has A/C and heavy duty tow package. It has ABS. This Jeep has the relay/fuse box on the passenger side of the engine bay with the engine control computer located parallel the air box on the driver side. The cover...

Hi All, I replaced both ball joints on my 1992 XJ 4.0 4X4 Auto tranny. Replacement seemed to go well. I believe I completely pressed new joints into the yoke. Both seem even with the milled surface on the yoke. I installed the knuckle and tightened the lower ball joint nut to 75 ft-lb...

Hi All, I've a 1992 XJ 4.0 4x4 auto tranny. I have about 3K miles on new pads and rotors. I've tried two types of new pads. This vehicle HAD the ABS unit, which I removed. I simply routed master cylinder outs to front and to back brake hydraulic lines, eliminating the ABS. Under normal...

Hi All, I have a 1992 XJ I-6 auto transmission 4X4. The recommended antifreeze concentration is 50/50 water/ethylene glycol (the green stuff). I'm in San Diego. My Jeep never sees very low temperatures. Antifreeze performs three functions. It lowers the point at which coolant freezes...

Has anyone modified the 1992 stock seats, which in my XJ are NOT electric, so that they can recline more than the current roughly 50 degrees from vertical?

Hi All, I've heard a rumor that there exists a all-metal replacement for the XJ plastic heater control valve. I've heard it is a Ford part. One of the hoses to thermostat on my 1992 XJ 4.0 heater control valve simply broke off with the plastic nipple of the HCV inside it. Luck this happened...

Hi All, I'm installing a new radiator in my 1992 Jeep XJ 4.0 automatic. This radiator provides cooing for the engine and also for the automatic transmission. There are two rubber oil lines lines from the automatic transmission to the side of this radiator. These slide and snap onto tubes...

Rock Rails for '92 XJ for sale in San Diego North County (Encinitas) $150. These have no damage. Just need paint. These are similar to Quadratec https://www.quadratec.com/products/12249_750X_PG.htm Quadratec wants $366 email [email protected]. I probably won't see any NAXJA PM very quickly...

Hi All, Replaced my factory gas tank with new. Turns out the old one is in good shape. No dents, one exterior surface rust point on top about the size of a nickel. Free. Take it away from Encinitas CA. Mike