TSBs

Ok here is my question. I have been searching all over this site and many others for the TSBs on my Jeep. I have seen all of the ones on Alldata's site and that is what promted me to start the search. Can anyone point me to a site or place whwre I can get the information contained in the TSBs instead of just the number and what they are all about? TIA


Ray

Check your local library. Mine has an account w/ Alldata. The librarians set you up at computer and away you go to any TSB you want.

I will have to try that. Only problem is getting to a library. They got me on 12s right now that is why I was asking if there was any place on line that had them. Thanks though.


Ray

Tell me which of these you want in full and I'll pm to you.


24-003-03 05/23/2003 A/C - System Sealer Usage Prohibition
18-008-03 03/07/2003 Engine Controls - Co-Pilot Support/Cable Selection
24-009-02 10/28/2002 A/C - System Leak Detection
18-020-02 06/24/2002 Engine Controls - Flash Reprogramming Failure
23-026-02 06/10/2002 Body/Frame - Floor Pan Corrosion
23-017-02 05/20/2002 Doors - Sagging/Creaking Sound
08-025-01 11/23/2001 Air Bag - On/Off Switches
19-009-01 10/26/2001 Driver Airbag - Trim Cover Service
08-010-01 05/25/2001 Airbag/Clock Spring - Service
18-012-01 05/25/2001 Generic Scan Tool - Reference Information
25-003-01 02/23/2001 PCM - MIL ON/Erroneous DTC P1398 (or $BA)
08-006-00A 12/29/2000 Wiring - Revised Splicing Procedure
23-008-00B 11/24/2000 Child Seat - Tether Anchor Part Numbers & Labor Time
21-04-00 06/30/2000 TCM - MIL ON/DTC P1763 Set
18-08-00 06/23/2000 MIL ON, Erroneous DTC P0107 Set
879 06/01/2000 Recall - Front Brake Rotor Corrosion
05-05-00 05/26/2000 Rear Brakes - Clunk or Thump When Brakes Are Applied
NHTSA00V136000 05/10/2000 Recall 00V136000: Front Disc Brake Rotor Corrosion
860 05/01/2000 Recall - Airbag Control Module Internal Corrosion
NHTSA00V105000 04/07/2000 Recall 00V105000: Air Bag Light On/Accidental Deployment
08-11-00 03/24/2000 CD Player - CD Compatibility
26-01-00N 01/01/2000 Engine Controls - O2 Sensor Diagnostic Update
08-34-99 10/08/1999 Headlamps - Momentarily Flicker
23-35-99A 10/01/1999 Child Seat Tether Anchor - Labor/Parts Identification
26-10-99I 10/01/1999 ABS - Kelsey Hayes EBC-5H, EBC 310 Test Revisions
02-12-99 08/20/1999 Front End Alignment - Adjustable/Offset Ball Joints
08-23-99 07/09/1999 Radio Communication Equipment - Recommendations
24-13-99 07/02/1999 A/C Evaporator - Freeze Up
02-08-99 06/25/1999 Front Shock Absorber - Rattle/Knock
18-12-99 06/18/1999 Leak Detection Pump - Monitor Test
08-07-99 05/12/1999 Power Distribution Center - Service
21-08-99 04/30/1999 A/T - Buzz/Whining in Reverse When Cold
02-03-99 04/23/1999 Leaf Spring - Retainer Clamp Availability
26-03-99G 03/01/1999 Brakes - Teves Mark IVG and Mark 20 ABS Revisions
26-01-99D 01/01/1999 ABS/TCS - Diagnostic Test Revisions
08-17-98C 12/30/1998 Air Bag System - ON-OFF Switch Availibility
14-06-98 12/11/1998 Fuel Tank - Rattling/Knocking/Gurgling Noises
25-02-98 10/23/1998 I/M Testing - OBDII CARB Readiness Monitor Information
05-03-98A 08/28/1998 Front Brakes - Pedal Pulsation
21-09-98 07/31/1998 Transfer Case Shifter - Creaking/Thumping Noise
18-24-98 07/31/1998 PCM - Light Spark Knock Condition
08-36-98 07/24/1998 Auto Computers - Y2K Effects
18-22-98 06/12/1998 MIL ON, Engine Misfire DTC's Set
18-21-98 06/05/1998 Powertrain Control Module - Service Precaution
755 06/01/1998 Recall - Fuel Tank Sending Unit
23-21-98 05/15/1998 Front Seat - Squeaking Noise
08-19-98 05/08/1998 ABS - Connector Repair
14-03-98 05/01/1998 Fuel Pressure Gauge Adapter - Usage
26-05-98D 05/01/1998 Engine Controls/Electronics/Emissions - Manual Revisions
03-01-98 03/27/1998 Drive Line - Vibration/Droning Noise Over 60 Mph
11-04-98 03/27/1998 Exhaust System - Squeak in Cold Weather
24-03-98 03/20/1998 Heater A/C Actuator - Squeaking Noise
05-02-98 03/13/1998 Front Brakes - One Click on Initial Application
18-08-98 02/27/1998 PCM - Failure to Mature Diagnostic Codes
23-03-98 01/30/1998 Doors/Locks - Inoperative/Binding
26-01-98D 01/01/1998 Brakes - Kelsey Hayes ABS Manual Revisions
23-66-97 12/12/1997 Firewall/Footwell - Noise/Air/Water Leaks
26-12-97F 12/01/1997 Brakes - Teves Mark IV/Teves Mark 20 ABS Revisions
26-12-97C 12/01/1997 Brakes - Bendix ABX 4 ABS System Test Revisions
14-08-97 11/21/1997 Engine - High Driveability Index Fuels
NHTSA97V194000 11/20/1997 Recall 97V194000: Fuel Level Sending Unit Defect
NHTSA97V194000 11/04/1997 Recall 97V194000: Defective Fuel Gauge Sender
23-54-97 10/10/1997 Rear Washer Fluid Nozzle - Washer Fluid Leaks
24-13-97 10/03/1997 A/C Manifold - Refrigerant Leaks
08-27-97A 09/26/1997 Radio/CD Player - Inoperative
08-32-97 09/19/1997 Airbag - NHTSA Authorized Deactivation
23-44-97 08/08/1997 Windshield/Door Glass Run - Wind Noise
26-08-97 08/01/1997 Brakes - Kelsey-Hayes ABS System Diagnostic Revisions
08-19-97A 07/25/1997 Fuel Gauge - Inaccurate
24-11-97 07/11/1997 A/C Evaporator - Emits Odors
08-23-97 07/11/1997 Rear Wiper Blade - Update
08-25-97 07/11/1997 Windshield Washer Bottle - Fills Too Slowly
19-09-97 06/13/1997 Steering Column - Clicking Noise When Turning
22-01-97 06/13/1997 Tire & Wheel - Runout
26-06-97G 06/01/1997 Brakes - ABS Diagnostic Procedures Revision
07-03-97 05/09/1997 Engine - Coolant Recommendations
232197 04/04/1997 Steering Column Boot - Cold Air/Noise to Interior
232097 04/04/1997 Front Door - Rattles/Clunks
231897 04/04/1997 Roof Rack - Rattles
712 04/01/1997 Recall - Passenger Air Bag Safety
090197 03/28/1997 Engine - Ticking Noise When Warm
231397 03/28/1997 Lower Instrument Panel Knee Blocker - Rattle
050697 03/28/1997 Park Brake Cables - Knocking/Banging Noise
181297 03/14/1997 PCM - Erroneous MIL ON/Driveability Improvements
23-03-97 02/14/1997 Black Plastic Body Components - Chalky Residue
080197 02/03/1997 PCM - Wire Harness Connector Repair Package
02-07-96 12/06/1996 Lower Control Arm - Grinding or Scraping Noise
236996 11/22/1996 Paint - Fallout Damage Repair
211596 11/08/1996 A/T - Quick Connect Removal & Reconnect Procedure
050996 10/14/1996 Brakes - Noise Explanation

I'd like the one on 08-19-97A 07/25/1997 Fuel Gauge - Inaccurate if you don't mind.

NO: 08-19-97 Rev. A

GROUP: Electrical

DATE: Jul. 25, 1997
SUBJECT:
Fuel Gauge Accuracy

THIS BULLETIN SUPERSEDES TECHNICAL SERVICE BULLETIN 08-19-97, DATED MAY 9, 1997, WHICH SHOULD BE REMOVED FROM YOUR FILES. THE BULLETIN IS BEING REVISED TO INCLUDE XJ AND TJ MODELS AND TO REVISE THE PART NUMBERS. THE REVISIONS ARE HIGHLIGHTED WITH **ASTERISKS**.
MODELS:
**1997 (TJ) Wrangler**
**1997 (XJ) Cherokee**
1997 (ZJ) Grand Cherokee
1997 (ZG) Grand Cherokee (International Markets)

SYMPTOM/CONDITION:

The fuel gauge may not read accurately. The vehicle may run out of fuel with the gauge reading 1/4 to 1/8 tank. A separate sending unit has been released, which was previously only available as part of the fuel pump module assembly.

DIAGNOSIS:

Using the appropriate Body Diagnostic Manual, check the gauge in the instrument cluster. If the fuel gauge is operating correctly and the symptoms are present, perform the Repair Procedure.

**PARTS REQUIRED:**

1 05010176AA Level Sending Unit (XJ - ZJ)
1 04897756AC Level Sending Unit (TJ - 15 gallon)
1 04897757AB Level Sending Unit (TJ - 19 gallon)

REPAIR PROCEDURE:

This bulletin involves replacing the fuel level sending unit.
1. Relieve the fuel pressure from the system, drain the fuel from the tank and remove the fuel tank from the vehicle using the procedures outlined in the appropriate service manual.

2. Remove the fuel pump module lock nut using special tool number 6856 and remove the module.

3. Disconnect the level sensor wire leads from the module connector and remove the level sensor.

4. Install the new level sensor listed above, and connect the wire leads to the module.

5. Install the pump module using the new gasket supplied and tighten the lock nut to 54 Nm (40 ft. lbs.), using special tool 6856.

6. Install the fuel tank and refill it with the fuel removed previously.

POLICY: Reimbursable within the provisions of the warranty.
TIME ALLOWANCE:
Labor Operation No:

14-50-02-96 Fuel Tank Sending Unit - Replace
(XJ/ZJ) 1.6 Hrs.
(YJ) 0.9 Hrs.

14-50-01-94 With Skid Plate - Add 0.3 Hrs.

FAILURE CODE: P8 - New Part

yea, you are screwed, the sender that the recall covers is for 97 only, the fact that they all fail the same way in 98, 99 just means they wormed out from recalling those too. The main reason the 97 was covered was the result of a lawsuit....woman driving alone, at nite, dangerous, etc etc etc....

RichP said:

yea, you are screwed, the sender that the recall covers is for 97 only, the fact that they all fail the same way in 98, 99 just means they wormed out from recalling those too. The main reason the 97 was covered was the result of a lawsuit....woman driving alone, at nite, dangerous, etc etc etc....

Click to expand...

Go figure!!! Now how can they get away with something like that? Cause mine's been periodically reading 1/4 to 1/8 a tank off,

Geez, ya know when it rains it pours. Valve Cover Gasket, Engine skipping, t-case leaking....AGAIN, rear brake drums lock up instantly in the rain......now what!?

But I guess it's part of owning a Jeep, and stuff like seals and gaskets and spark plugs are all common wear and tear items. guess the pervious owner saw this coming and dumped the car...